The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler

Dawit Beza

doi:doi:10.11648/j.ajcbm.20220601.16

| Peer-Reviewed

The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler

Dawit Beza

Published in American Journal of Construction and Building Materials (Volume 6, Issue 1)

Received: 5 January 2022 Accepted: 29 January 2022 Published: 9 June 2022

Views: Downloads:

Download PDF

Share This Article

Twitter
Linked In
Facebook

Abstract

In developing countries' construction industry the use of conventional construction material and conventional construction technologies makes construction expensive and hazardous to the environment so that the use of alternative construction material and construction technologies in our construction industry is very important. In this study the behavior of slurry infiltrated fibrous concrete with waste marble dust as filler are studied. Slurry infiltrated fibrous concrete is special type of steel fiber concrete (SFC) with a high volume fraction of fiber it possesses high ductility and high mechanical properties with special application of SIFCON lamination for structural member of buildings and It improves the strength of concrete structural members up to 25% for normal concrete and up to 40% for fibrous reinforced concretes and used for remedial works for weaken concrete structural members of buildings. This type of concrete uses a matrix consisting of very fine particles or filler to enhance its fibrous interlock properties. The purpose of this paper is to study the possibility of using marble waste powder as fine fillers in slurry infiltrated fibrous concrete production. from previous studies the use of marble waste powder filler for concrete production improves property of flow able concrete up to a certain limit so that for this purpose four different serious of concrete were prepared by adding different dosage of WMP (0%, 10%, 20%, 30%, 40%) by weight of cement. To study the performance of SIFCON a total of eighteen samples were prepared with the addition of waste marble powder with different additional range (0%, 10%, 20%, 30%, 40%) for each replacement C-30 were prepared the testes were on the mechanical properties of SIFCON that is compressive, tensile and flexural strength of the concrete and UPV test are conducted to check the porosity of the samples. The results indicate that the amount of ingredients (cement, sand) is reduced up to 10% because the fresh volume increased up to 15%. Finally XRD is conducted to observe the microstructure of the samples. The use of waste marble powder in SIFCON as fine filler improves the consistency and workability up to 30% usage so that from previous literature that is because the lubricating power of very fine limestone particle and also compressive strength, tensile, flexural strength shows progress up 30% usage and the optimum usage is 30% more than this percentage I observed reduction in workability and also in compressive, tensile and flexural strength of SIFCON.

Published in	American Journal of Construction and Building Materials (Volume 6, Issue 1)
DOI	10.11648/j.ajcbm.20220601.16
Page(s)	70-79
Creative Commons	This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.
Copyright	Copyright © The Author(s), 2022. Published by Science Publishing Group

Keywords

Fine Filler, Waste Marble Dust, Compressive Strengths, Flexural Strength and Tensile Strength

References

[1]	AcAhed Habib and Maan Habibcess, O. (2020). We are IntechOpen, the world’s leading publisher of Open Access books Built by scientists, for scientists TOP 1% Sustainable Recycling of Marble Dust as Cement Replacement in Concrete: Advances and Recent.
[2]	Ahmad, J., Manan, A., Ali, A., M, T. I., Zaid, O., & Ullah, R. (2020). Effects of Partially and Totally Substitution of Marble Waste as a Fine Aggregate on Workability and Mechanical Performance of Concrete. 10. https://doi.org/10.37421/jcce.2020.10.367
[3]	Ali, A. S., & Riyadh, Z. (2018). Experimental and Numerical Study on the Effects of Size and type of Steel Fibers on the (SIFCON) Concrete Specimens. 13 (2), 1344–1353.
[4]	Allam, M. E., Bakhoum, E. S., Ezz, H., & Garas, G. L. (2016). influence of using granite waste on the mechanical properties of green concrete. 11 (5), 2805–2811.
[5]	Alyousef, R., Benjeddou, O., Soussi, C., Khadimallah, M. A., & Mohamed, A. M. (2019). Effects of Incorporation of Marble Powder Obtained by Recycling Waste Sludge and Limestone Powder on Rheology, Compressive Strength, and Durability of Self-Compacting Concrete. 2019.
[6]	Ashish, D. K., Verma, S. K., Kumar, R., & Sharma, N. (2016). Properties of concrete incorporating sand and cement with waste marble powder. Advances in Concrete Construction, 4 (2), 145–160. https://doi.org/10.12989/acc.2016.4.2.145
[7]	Cagin, G., Bilir, T., & Artir, R. (2016). Durability Properties of Concrete Produced by Marble Waste as Aggregate or Mineral Additives. Procedia Engineering, 161, 543–548. https://doi.org/10.1016/j.proeng.2016.08.689
[8]	Daniel, J. I., Ahmad, S. H., Arockiasamy, M., Ball, H. P., Batson, G. B., Criswell, M. E., Dorfmueller, D. P., Fernandez, A. V, Gale, D. M., Antonio, J., Hackman, L. E., Hoff, G. C., Johnston, C. D., Leppert, M. A., Macdonald, C. N., Mangat, P. S., Marsh, H. N., Mitchell, N. C., Molloy, H. J., … Zollo, R. F. (2002). Report on Fiber Reinforced Concrete Reported by ACI Committee 544 (Vol. 96, Issue Reapproved).
[9]	Dobiszewska, M., Pichór, W., & Szołdra, P. (2019). Effect of basalt powder addition on properties of mortar. 06002, 1–7.
[10]	Espacios, H. R. Autores, L. O. S., Erica, Z., & Renan, C. (2017). Análise e perspectivas de alternativas para destinação de resíduos de rochas ornamentais através de um estudo bibliométrico.
[11]	Faiz, A. (2018). utilization of waste quarry dust and. 1–14.
[12]	Hameed, D. H. (2019). Slurry Infiltrated Fiber Concrete as Sustainable Solution for Defective Buildings. 37 (1), 24–28.
[13]	Kumar, A., & Thakur, A. (2018). strength behaviour of concrete. 9 (7), 1058–1065.
[14]	Mittal, S., Sharma, R. K., & Yadav, P. (2016). Practicality of Consumption of Waste Marble Dust As a Substitution of Real Sand As a Changer in Concrete. 500–502.
[15]	Naedir, N., Tikur, E., & Ababa, A. (2017). Marble in Ethiopia Marble has been mined in many.
[16]	Pal, S., Pramanik, T., Singh, A., & Kumar, S. (2016). Effects of Partial Replacement of Cement with Marble Dust Powder on Properties of Concrete. 3 (03), 41–45.
[17]	Pardeshi, S. (2017). repair, restoration and strengthening of buildings. 4 (3), 121–124.
[18]	Profile, S. E. E. (2015). effect of the lime content in marble powder for producing high effect of the lime content in marble powder for producing high strength concrete. April 2013.
[19]	Raghunath, P. N., Suguna, K., Karthick, J., & Sarathkumar, B. (2019). Mechanical and durability characteristics of marble-powder-based high-strength concrete. 26, 3159–3164. https://doi.org/10.24200/sci.2018.4953.1005
[20]	Rahim, M. A., Ghazaly, Z., Nurazira, R., Mamat, R., Azizan, M. A., Isa, N. F., & Shahidan, S. (2016). Experimental Study of Slurry Infiltrated Fiber Reinforced Concrete Experimental Study of Slurry Infiltrated Fiber Reinforced Concrete. January. https://doi.org/10.4028/www.scientific.net/MSF.857.363
[21]	Raj, E., Ishwar, P., Sharma, C., & Pbl, P. (2015). Utilization of “Marble Slurry” In Cement Concrete Replacing Fine Agreegate. 1, 55–58.
[22]	Sampath, P., & Asha, P. (2019). Strength and Durability Properties of SIFCON with Silica Fume and Waste Binding Wire. 3, 917–923.
[23]	Search, H., Journals, C., Contact, A., Iopscience, M., Conf, I. O. P., Environ, E., & Address, I. P. (2017). Effects of slag on flexural strength of slurry infiltrated fibrous concrete. 012036.
[24]	Singam, P. S. R., & Susmitha, N. (2018). An Experimental study on Behaviour of Slurry Infiltrated Fibrous Concrete (SIFCON) Produced by Partial Replacement of Cement with Metakaolin and Fine Aggregate with Robosand. 4290–4302.
[25]	S. Soundarya, S. Suresh Babu, V. S. Satheesh, & P. G. Student. (2018). Flexural behavior of SIFCON beams under three point loading. 3 (3), 73–77.
[26]	Tc odimegwa. (2018). the use of industrial wastes as filler in concrete /mortar.
[27]	Upadhyay, H., Shah, P., & George, E. (2011). Testing and Mix Design Method of Self- Compacting Concrete Hardik. May, 3–6.
[28]	Uysal, M. (2018). The Use of Waste Maroon Marble Powder and Iron Oxide Pigment in the Production of Coloured Self-Compacting Concrete. 2018.
[29]	Vijayakumar, M., & Kumar, P. D. (2017). study on strength properties of sifcon. 235–238.
[30]	Zhang, J., Cai, D., Wang, T., Hu, Q., & Li, K. (2018). Experimental analysis on the effects of artificial marble waste powder on concrete performance. 347–362. https://doi.org/10.3166/ACSM.42.347-362

Cite This Article

Plain Text BibTeX RIS

APA Style

Dawit Beza. (2022). The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. American Journal of Construction and Building Materials, 6(1), 70-79. https://doi.org/10.11648/j.ajcbm.20220601.16

Copy | Download

ACS Style

Dawit Beza. The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. Am. J. Constr. Build. Mater. 2022, 6(1), 70-79. doi: 10.11648/j.ajcbm.20220601.16

Copy | Download

AMA Style

Dawit Beza. The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. Am J Constr Build Mater. 2022;6(1):70-79. doi: 10.11648/j.ajcbm.20220601.16

Copy | Download

@article{10.11648/j.ajcbm.20220601.16,
  author = {Dawit Beza},
  title = {The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler},
  journal = {American Journal of Construction and Building Materials},
  volume = {6},
  number = {1},
  pages = {70-79},
  doi = {10.11648/j.ajcbm.20220601.16},
  url = {https://doi.org/10.11648/j.ajcbm.20220601.16},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ajcbm.20220601.16},
  abstract = {In developing countries' construction industry the use of conventional construction material and conventional construction technologies makes construction expensive and hazardous to the environment so that the use of alternative construction material and construction technologies in our construction industry is very important. In this study the behavior of slurry infiltrated fibrous concrete with waste marble dust as filler are studied. Slurry infiltrated fibrous concrete is special type of steel fiber concrete (SFC) with a high volume fraction of fiber it possesses high ductility and high mechanical properties with special application of SIFCON lamination for structural member of buildings and It improves the strength of concrete structural members up to 25% for normal concrete and up to 40% for fibrous reinforced concretes and used for remedial works for weaken concrete structural members of buildings. This type of concrete uses a matrix consisting of very fine particles or filler to enhance its fibrous interlock properties. The purpose of this paper is to study the possibility of using marble waste powder as fine fillers in slurry infiltrated fibrous concrete production. from previous studies the use of marble waste powder filler for concrete production improves property of flow able concrete up to a certain limit so that for this purpose four different serious of concrete were prepared by adding different dosage of WMP (0%, 10%, 20%, 30%, 40%) by weight of cement. To study the performance of SIFCON a total of eighteen samples were prepared with the addition of waste marble powder with different additional range (0%, 10%, 20%, 30%, 40%) for each replacement C-30 were prepared the testes were on the mechanical properties of SIFCON that is compressive, tensile and flexural strength of the concrete and UPV test are conducted to check the porosity of the samples. The results indicate that the amount of ingredients (cement, sand) is reduced up to 10% because the fresh volume increased up to 15%. Finally XRD is conducted to observe the microstructure of the samples. The use of waste marble powder in SIFCON as fine filler improves the consistency and workability up to 30% usage so that from previous literature that is because the lubricating power of very fine limestone particle and also compressive strength, tensile, flexural strength shows progress up 30% usage and the optimum usage is 30% more than this percentage I observed reduction in workability and also in compressive, tensile and flexural strength of SIFCON.},
 year = {2022}
}

Copy | Download

TY  - JOUR
T1  - The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler
AU  - Dawit Beza
Y1  - 2022/06/09
PY  - 2022
N1  - https://doi.org/10.11648/j.ajcbm.20220601.16
DO  - 10.11648/j.ajcbm.20220601.16
T2  - American Journal of Construction and Building Materials
JF  - American Journal of Construction and Building Materials
JO  - American Journal of Construction and Building Materials
SP  - 70
EP  - 79
PB  - Science Publishing Group
SN  - 2640-0057
UR  - https://doi.org/10.11648/j.ajcbm.20220601.16
AB  - In developing countries' construction industry the use of conventional construction material and conventional construction technologies makes construction expensive and hazardous to the environment so that the use of alternative construction material and construction technologies in our construction industry is very important. In this study the behavior of slurry infiltrated fibrous concrete with waste marble dust as filler are studied. Slurry infiltrated fibrous concrete is special type of steel fiber concrete (SFC) with a high volume fraction of fiber it possesses high ductility and high mechanical properties with special application of SIFCON lamination for structural member of buildings and It improves the strength of concrete structural members up to 25% for normal concrete and up to 40% for fibrous reinforced concretes and used for remedial works for weaken concrete structural members of buildings. This type of concrete uses a matrix consisting of very fine particles or filler to enhance its fibrous interlock properties. The purpose of this paper is to study the possibility of using marble waste powder as fine fillers in slurry infiltrated fibrous concrete production. from previous studies the use of marble waste powder filler for concrete production improves property of flow able concrete up to a certain limit so that for this purpose four different serious of concrete were prepared by adding different dosage of WMP (0%, 10%, 20%, 30%, 40%) by weight of cement. To study the performance of SIFCON a total of eighteen samples were prepared with the addition of waste marble powder with different additional range (0%, 10%, 20%, 30%, 40%) for each replacement C-30 were prepared the testes were on the mechanical properties of SIFCON that is compressive, tensile and flexural strength of the concrete and UPV test are conducted to check the porosity of the samples. The results indicate that the amount of ingredients (cement, sand) is reduced up to 10% because the fresh volume increased up to 15%. Finally XRD is conducted to observe the microstructure of the samples. The use of waste marble powder in SIFCON as fine filler improves the consistency and workability up to 30% usage so that from previous literature that is because the lubricating power of very fine limestone particle and also compressive strength, tensile, flexural strength shows progress up 30% usage and the optimum usage is 30% more than this percentage I observed reduction in workability and also in compressive, tensile and flexural strength of SIFCON.
VL  - 6
IS  - 1
ER  -

Copy | Download

Author Information

Dawit Beza

Department of Construction Technology and Management, College of Architecture and Civil Engineering, Addis Ababa Science and Technology University, Addis Ababa, Ethiopia

Download PDF

Sections

Plain Text BibTeX RIS

APA Style

Dawit Beza. (2022). The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. American Journal of Construction and Building Materials, 6(1), 70-79. https://doi.org/10.11648/j.ajcbm.20220601.16

Copy | Download

ACS Style

Dawit Beza. The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. Am. J. Constr. Build. Mater. 2022, 6(1), 70-79. doi: 10.11648/j.ajcbm.20220601.16

Copy | Download

AMA Style

Dawit Beza. The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler. Am J Constr Build Mater. 2022;6(1):70-79. doi: 10.11648/j.ajcbm.20220601.16

Copy | Download

@article{10.11648/j.ajcbm.20220601.16,
  author = {Dawit Beza},
  title = {The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler},
  journal = {American Journal of Construction and Building Materials},
  volume = {6},
  number = {1},
  pages = {70-79},
  doi = {10.11648/j.ajcbm.20220601.16},
  url = {https://doi.org/10.11648/j.ajcbm.20220601.16},
  eprint = {https://article.sciencepublishinggroup.com/pdf/10.11648.j.ajcbm.20220601.16},
  abstract = {In developing countries' construction industry the use of conventional construction material and conventional construction technologies makes construction expensive and hazardous to the environment so that the use of alternative construction material and construction technologies in our construction industry is very important. In this study the behavior of slurry infiltrated fibrous concrete with waste marble dust as filler are studied. Slurry infiltrated fibrous concrete is special type of steel fiber concrete (SFC) with a high volume fraction of fiber it possesses high ductility and high mechanical properties with special application of SIFCON lamination for structural member of buildings and It improves the strength of concrete structural members up to 25% for normal concrete and up to 40% for fibrous reinforced concretes and used for remedial works for weaken concrete structural members of buildings. This type of concrete uses a matrix consisting of very fine particles or filler to enhance its fibrous interlock properties. The purpose of this paper is to study the possibility of using marble waste powder as fine fillers in slurry infiltrated fibrous concrete production. from previous studies the use of marble waste powder filler for concrete production improves property of flow able concrete up to a certain limit so that for this purpose four different serious of concrete were prepared by adding different dosage of WMP (0%, 10%, 20%, 30%, 40%) by weight of cement. To study the performance of SIFCON a total of eighteen samples were prepared with the addition of waste marble powder with different additional range (0%, 10%, 20%, 30%, 40%) for each replacement C-30 were prepared the testes were on the mechanical properties of SIFCON that is compressive, tensile and flexural strength of the concrete and UPV test are conducted to check the porosity of the samples. The results indicate that the amount of ingredients (cement, sand) is reduced up to 10% because the fresh volume increased up to 15%. Finally XRD is conducted to observe the microstructure of the samples. The use of waste marble powder in SIFCON as fine filler improves the consistency and workability up to 30% usage so that from previous literature that is because the lubricating power of very fine limestone particle and also compressive strength, tensile, flexural strength shows progress up 30% usage and the optimum usage is 30% more than this percentage I observed reduction in workability and also in compressive, tensile and flexural strength of SIFCON.},
 year = {2022}
}

Copy | Download

TY  - JOUR
T1  - The Behavior of Slurry Infiltrated Fibrous Concrete with Waste Marble Dust as a Filler
AU  - Dawit Beza
Y1  - 2022/06/09
PY  - 2022
N1  - https://doi.org/10.11648/j.ajcbm.20220601.16
DO  - 10.11648/j.ajcbm.20220601.16
T2  - American Journal of Construction and Building Materials
JF  - American Journal of Construction and Building Materials
JO  - American Journal of Construction and Building Materials
SP  - 70
EP  - 79
PB  - Science Publishing Group
SN  - 2640-0057
UR  - https://doi.org/10.11648/j.ajcbm.20220601.16
AB  - In developing countries' construction industry the use of conventional construction material and conventional construction technologies makes construction expensive and hazardous to the environment so that the use of alternative construction material and construction technologies in our construction industry is very important. In this study the behavior of slurry infiltrated fibrous concrete with waste marble dust as filler are studied. Slurry infiltrated fibrous concrete is special type of steel fiber concrete (SFC) with a high volume fraction of fiber it possesses high ductility and high mechanical properties with special application of SIFCON lamination for structural member of buildings and It improves the strength of concrete structural members up to 25% for normal concrete and up to 40% for fibrous reinforced concretes and used for remedial works for weaken concrete structural members of buildings. This type of concrete uses a matrix consisting of very fine particles or filler to enhance its fibrous interlock properties. The purpose of this paper is to study the possibility of using marble waste powder as fine fillers in slurry infiltrated fibrous concrete production. from previous studies the use of marble waste powder filler for concrete production improves property of flow able concrete up to a certain limit so that for this purpose four different serious of concrete were prepared by adding different dosage of WMP (0%, 10%, 20%, 30%, 40%) by weight of cement. To study the performance of SIFCON a total of eighteen samples were prepared with the addition of waste marble powder with different additional range (0%, 10%, 20%, 30%, 40%) for each replacement C-30 were prepared the testes were on the mechanical properties of SIFCON that is compressive, tensile and flexural strength of the concrete and UPV test are conducted to check the porosity of the samples. The results indicate that the amount of ingredients (cement, sand) is reduced up to 10% because the fresh volume increased up to 15%. Finally XRD is conducted to observe the microstructure of the samples. The use of waste marble powder in SIFCON as fine filler improves the consistency and workability up to 30% usage so that from previous literature that is because the lubricating power of very fine limestone particle and also compressive strength, tensile, flexural strength shows progress up 30% usage and the optimum usage is 30% more than this percentage I observed reduction in workability and also in compressive, tensile and flexural strength of SIFCON.
VL  - 6
IS  - 1
ER  -

Copy | Download